ILLINOIS OIL PRODUCTS INC -- 7060 CLEANING SOLVENT -- 6850-00F025525
<pre>===================== Product Identification =====================
Product ID:7060 CLEANING SOLVENT
MSDS Date:02/15/1988
FSC:6850
NIIN:00F025525
=== Responsible Party ===
Company Name:ILLINOIS OIL PRODUCTS INC
Address:321 24TH ST ILLINOIS OIL BLDG
City:ROCK ISLAND
State:IL
ZIP:61201-8818
Country:US
Info Phone Num:309-786-4474
Emergency Phone Num:309-786-4474
CAGE:7J286
=== Contractor Identification ===
Company Name:ILLINOIS OIL PRODUCTS INC
Address:321 24TH ST
Box:City:ROCK ISLAND
State:IL
ZIP:61201-8818
Country:US
Phone:309-786-4474;800-447-6055
CAGE:7J286
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS *92/3*
CAS:64742-88-7
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, REDNESS,
TEARING, & BLURRED VISION. INHALATION: NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, & HEADACHE.
INGESTION: ASPIRATION OF MATERIAL INTO LUNGS DUE TO VOMITING CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. GASTROINTESTINAL
IRRITATION/NAUSEA/VOMITING/DIARRHEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION, DEFATTING, & DERMATITIS.
INHALATION: POSSIBLE UNCONSCIOUSNESS, & ASPHYXIATION.
======================= First Aid Measures =======================
First Aid:EYES: WASH OUT W/COPIOUS AMOUNTS OF WATER. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIA L RESPIRATION. KEEP PERSON WARM & QUIET.
INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. KEEP PERSON
WARM & QUIET. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:37.8C
Lower Limits:1%
Extinguishing Media:CO2, DRY CHEMICAL, REGULAR FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL
FACE PIECE USED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR/MAY TRAVEL
ALONG GROUND/BE MOVED BY VENTILATION/IGNITE BY IGNITION SOURCES
DISTANT FROM MATERIAL HANDLING POINT. COMBUSTIBLE LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB ON PAPER/VERMICULITE/FLOOR
ABSORBENT. TRANSFER TO HOOD. LARGE: REMOVE IGNITION SOURCE.
EVACUATE AREA/WEAR PROTECTION. STOP AT SOURCE/DIKE/PUMP TO SALVAGE
TANK. SOAK REMAINING W/SAND/CLAY /EARTH/FLOOR ABSORBENT, SHOVEL
INTO CONTAINER.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE W/ADEQUATE
VENTILATION. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
CONTAINERS MAY STILL BE HAZARDOUS WHEN EMPTY.
Other Precautions:OBSERVE ALL PRECAUTIONS. PREVENT RUN-OFF TO
SEWERS/STREAMS, OR OTHER BODIES OF WATER. AVOID PROLONGED CONTACT
W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. USE EITHER AN ATMOSPHERE-SUPPLYING RESPIRATOR OR AN
AIR-PURIFYING RESPIRATOR FOR O RGANIC VAPORS.
Ventilation:GENERAL OR LOCAL EXHAUST SUFFICIENT TO MAINTAIN BELOW TLV.
Protective Gloves:IMPERVIOUS
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148.88C
Vapor Pres:2
Vapor Density:4.9
Spec Gravity:0.70
Evaporation Rate & Reference:(BU AC = 1): 70
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID W/HYDROCARBON ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, PILOT LIGHTS, OPEN FLAMES, FLARES,
ELECTRICAL SPARKS, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:TOXIC MATERIALS, CO, CO2, & VARIOUS
OTHER HYDROCARBON COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN
HOOD/SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT WORK.
REMAINING MATERIAL: ACCORDING TO REGS. LARGE SPILL: LIQUID
INCINERATION. CONTAMINATED ABSORBE NT: LANDFILL DEPOSIT. KEEP FROM
WATER AREA. UN1255
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.